In the present study, the yeast Rhodotorula glutinis has been assessed with the aim of producing microbial lipids from glycerol under different aeration conditions. For such a purpose, experiments were carried out in shake flasks, under different conditions of agitation (150 to 250 rpm) and aeration (2.5 to 5.0 of flask volume-to-medium volume ratio). Furthermore, their influence on fermentative parameters (lipid and cell concentration, biomass yield; lipid yield; and lipid volumetric productivity) has been investigated using a 22 full factorial design. The statistical analysis has revealed a strong influence of both variables on substrate consumption, lipid accumulation, cell growth and lipid productivity. As a whole, results suggest that higher aeration levels provide greater cell and lipid concentrations, and lipid volumetric productivity. The best results (4.5 g/L of lipids and QP = 0.95 g/L⋅day) were achieved at the highest aeration (5.0 flask volume-to-medium volume ratio) and agitation (250 rpm) levels. Their fatty acid profile showed that oleic acid was produced in greater quantity (53.5%), followed by linoleic acid (18.7%), palmitic acid (6.8%) and stearic acid (9.9%). The microbial oil presented viscosity of 39.3 cP at 50°C and free fatty acid content of 1.93% ± 0.08%. These are significant results and contribute to establishing operational conditions that maximize single-cell oil production from glycerol by Rhodotorula glutinis,i.e. an alternative source as renewable raw material for lipid-based biorefineries.
References
[1]
Jena, U., McCurdy, A.T., Warren, A., Summers, H., Ledbetter, R.N., Hoekman, S.K. and Quinn, J.C. (2015) Oleaginous Yeast Platform for Producing Biofuels via Co-Solvent Hydrothermal Liquefaction. Biotechnology for Biofuels, 8, 167.
https://doi.org/10.1186/s13068-015-0345-5
[2]
Carvalho, A.K.F.D. (2011) Sintese de biodiesel por transesterificacao pela rota etilica: Comparacao de desempenho de catalisadores heterogeneos. Doctoral Dissertation, Universidade de Sao Paulo, Sao Paulo.
[3]
Canakci, M. and Sanli, H. (2008) Biodiesel Production from Various Feedstocks and Their Effects on the Fuel Properties. Journal of Industrial Microbiology & Biotechnology, 35, 431-441. https://doi.org/10.1007/s10295-008-0337-6
[4]
Quintana, N., Van der Kooy, F., Van de Rhee, M.D., Voshol, G.P. and Verpoorte, R. (2011) Renewable Energy from Cyanobacteria: Energy Production Optimization by Metabolic Pathway Engineering. Applied Microbiology and Biotechnology, 91, 471-490. https://doi.org/10.1007/s00253-011-3394-0
[5]
Perez-Garcia, O., Escalante, F.M., de-Bashan, L.E. and Bashan, Y. (2011) Heterotrophic Cultures of Microalgae: Metabolism and Potential Products. Water Research, 45, 11-36. https://doi.org/10.1016/j.watres.2010.08.037
[6]
Chisti, Y. (2007) Biodiesel from Microalgae. Biotechnology Advances, 25, 294-306.
https://doi.org/10.1016/j.biotechadv.2007.02.001
[7]
Soccol, C.R., Neto, C.J.D., Soccol, V.T., Sydney, E.B., da Costa, E.S.F., Medeiros, A.B.P. and de Souza Vandenberghe, L.P. (2017) Pilot Scale Biodiesel Production from Microbial Oil of Rhodosporidium toruloides DEBB 5533 Using Sugarcane Juice: Performance in Diesel Engine and Preliminary Economic Study. Bioresource Technology, 223, 259-268. https://doi.org/10.1016/j.biortech.2016.10.055
[8]
Kong, W.B., Yang, H., Cao, Y.T., Song, H., Hua, S.F. and Xia, C.G. (2013) Effect of Glycerol and Glucose on the Enhancement of Biomass, Lipid and Soluble Carbohydrate Production by Chlorella vulgaris in Mixotrophic Culture. Food Technology and Biotechnology, 51, 62-69.
[9]
Li, Y., Zhao, Z.K. and Bai, F. (2007) High-Density Cultivation of Oleaginous Yeast Rhodosporidium toruloides Y4 in Fed-Batch Culture. Enzyme and Microbial Technology, 41, 312-317. https://doi.org/10.1016/j.enzmictec.2007.02.008
[10]
Tapia, E., Anschau, A., Coradini, A.L., Franco, T.T. and Deckmann, A.C. (2012) Optimization of Lipid Production by the Oleaginous Yeast Lipomyces Starkeyi by Random Mutagenesis Coupled to Cerulenin Screening. AMB Express, 2, 64.
https://doi.org/10.1186/2191-0855-2-64
[11]
Hsieh, C.H. and Wu, W.T. (2009) Cultivation of Microalgae for Oil Production with a Cultivation Strategy of Urea Limitation. Bioresource Technology, 100, 3921-3926.
https://doi.org/10.1016/j.biortech.2009.03.019
[12]
Easterling, E.R., French, W.T., Hernandez, R. and Licha, M. (2009) The Effect of Glycerol as a Sole and Secondary Substrate on the Growth and Fatty Acid Composition of Rhodotorula glutinis. Bioresource Technology, 100, 356-361.
https://doi.org/10.1016/j.biortech.2008.05.030
[13]
Rawat, I., Kumar, R.R., Mutanda, T. and Bux, F. (2013) Biodiesel from Microalgae: A Critical Evaluation from Laboratory to Large Scale Production. Applied Energy, 103, 444-467. https://doi.org/10.1016/j.apenergy.2012.10.004
[14]
Yazdani, S.S. and Gonzalez, R. (2007) Anaerobic Fermentation of Glycerol: A Path to Economic Viability for the Biofuels Industry. Current Opinion in Biotechnology, 18, 213-219. https://doi.org/10.1016/j.copbio.2007.05.002
[15]
Swinnen, S., Klein, M., Carrillo, M., McInnes, J., Nguyen, H.T.T. and Nevoigt, E. (2013) Re-Evaluation of Glycerol Utilization in Saccharomyces cerevisiae: Characterization of an Isolate That Grows on Glycerol without Supporting Supplements. Biotechnology for Biofuels, 6, 157. https://doi.org/10.1186/1754-6834-6-157
[16]
Li, Q., Du, W. and Liu, D. (2008) Perspectives of Microbial Oils for Biodiesel Production. Applied Microbiology and Biotechnology, 80, 749-756.
https://doi.org/10.1007/s00253-008-1625-9
[17]
Hall, M.J. and Ratledge, C. (1977) Lipid Accumulation in an Oleaginous Yeast (Candida 107) Growing on Glucose under Various Conditions in a One- and Two-Stage Continuous Culture. Applied and Environmental Microbiology, 33, 577-584.
[18]
Zara, G., Angelozzi, D., Belviso, S., Bardi, L., Goffrini, P., Lodi, T., Mannazzu, I., et al. (2009) Oxygen Is Required to Restore Flor Strain Viability and Lipid Biosynthesis under Fermentative Conditions. FEMS Yeast Research, 9, 217-225.
https://doi.org/10.1111/j.1567-1364.2008.00472.x
[19]
Ageitos, J.M., Vallejo, J.A., Veiga-Crespo, P. and Villa, T.G. (2011) Oily Yeasts as Oleaginous Cell Factories. Applied Microbiology and Biotechnology, 90, 1219-1227.
https://doi.org/10.1007/s00253-011-3200-z
[20]
Bligh, E.G. and Dyer, W.J. (1959) A Rapid Method of Total Lipid Extraction and Purification. Canadian Journal of Biochemistry and Physiology, 37, 911-917.
https://doi.org/10.1139/o59-099
[21]
Knight, J.A., Anderson, S. and Rawle, J.M. (1972) Chemical Basis of the Sulfo-Phospho-Vanillin Reaction for Estimating Total Serum Lipids. Clinical Chemistry, 18, 199-202.
[22]
Ichihara, K.I. and Fukubayashi, Y. (2009) Preparation of Fatty Acid Methyl Esters for Gas-Liquid Chromatography. Journal of Lipid Research, 51, 635-640.
https://doi.org/10.1194/jlr.D001065
[23]
American Oil Chemists’ Society (2004) Official Methods and Recommended Practices of the AOCS. 5th Edition, AOCS Press, Champaign.
[24]
Saenge, C., Cheirsilp, B., Suksaroge, T.T. and Bourtoom, T. (2011) Potential Use of Oleaginous Red Yeast Rhodotorula glutinis for the Bioconversion of Crude Glycerol from Biodiesel Plant to Lipids and Carotenoids. Process Biochemistry, 46, 210-218.
https://doi.org/10.1016/j.procbio.2010.08.009
[25]
Coelho, M.A.Z., Amaral, P.F.F. and Belo, I. (2010) Yarrowia lipolytica: An Industrial Workhorse. Current Research, Technology and Education Topics in Applied Microbiology and Microbial Biotechnology, 2, 930-940.
[26]
Machado Junior, F.R.D.S. (2010) Conversao por via biotecnologica de glicerina residual em biomassa de leveduras como fonte de proteinas e lipidios. Master’s Thesis.
[27]
Magdouli, S., Brar, S.K. and Blais, J.F. (2018) Morphology and Rheological Behaviour of Yarrowia lipolytica: Impact of Dissolved Oxygen Level on Cell Growth and Lipid Composition. Process Biochemistry, 65, 1-10.
https://doi.org/10.1016/j.procbio.2017.10.021
[28]
Kot, A.M., Blazejak, S., Kurcz, A., Gientka, I. and Kieliszek, M. (2016) Rhodotorula glutinis—Potential Source of Lipids, Carotenoids, and Enzymes for Use in Industries. Applied Microbiology and Biotechnology, 100, 6103-6117.
https://doi.org/10.1007/s00253-016-7611-8
[29]
Sitepu, I.R., Sestric, R., Ignatia, L., Levin, D., German, J.B., Gillies, L.A. and Boundy-Mills, K.L. (2013) Manipulation of Culture Conditions Alters Lipid Content and Fatty Acid Profiles of a Wide Variety of Known and New Oleaginous Yeast Species. Bioresource Technology, 144, 360-369.
https://doi.org/10.1016/j.biortech.2013.06.047
[30]
Zhang, Z., Zhang, X. and Tan, T. (2014) Lipid and Carotenoid Production by Rhodotorula glutinis under Irradiation/High-Temperature and Dark/Low-Temperature Cultivation. Bioresource Technology, 157, 149-153.
https://doi.org/10.1016/j.biortech.2014.01.039
[31]
Moreira, A.B., Perez, V.H., Zanin, G.M. and de Castro, H.F. (2007) Biodiesel Synthesis by Enzymatic Transesterification of Palm Oil with Ethanol Using Lipases from Several Sources Immobilized on Silica-PVA Composite. Energy & Fuels, 21, 3689-3694. https://doi.org/10.1021/ef700399b
[32]
Brock, J., Nogueira, M.R., Zakrzevski, C., de Castilhos Corazza, F., Corazza, M.L. and de OLIVEIRA, J.V. (2008) Determinacao experimental da viscosidade e condutividade térmica de oleos vegetais. Ciencia e Tecnologia de Alimentos, 28, 564-570. https://doi.org/10.1590/S0101-20612008000300010
[33]
Ros, P., Da, C.M., Silva, C.S., Silva-Stenico, M.E., Fiore, M.F. and Castro, H.F.D. (2013) Assessment of Chemical and Physico-Chemical Properties of Cyanobacterial Lipids for Biodiesel Production. Marine Drugs, 11, 2365-2381.
https://doi.org/10.3390/md11072365
[34]
Carvalho, A.K.F.D. (2015) Avaliacao do potencial do fungo filamentoso Mucor circinelloides como fonte de lipase e lipidios para a producao de biodiesel dentro do conceito de biorrefinaria. Doctoral Dissertation, Universidade de Sao Paulo, Sao Paulo.
[35]
Porphy, S.J. and Farid, M.M. (2012) Feasibility Study for Production of Biofuel and Chemicals from Marine Microalgae Nannochloropsis sp. Based on Basic Mass and Energy Analysis. ISRN Renewable Energy, 2012, Article ID: 156824.
https://doi.org/10.5402/2012/156824
