Operations of Knapsack Sprayer and Its Impacts on Physiological Parameters of Selected Operators

The study was aimed at determining the impacts of operating Manually Operated Hand Lever Knapsack Sprayers (MOHLKS) on physiological responses of the operators as dependent on anthropometric variations and sex. Twenty eight subjects, (4 female, 24 male) Mean ± SD: Age 22.5 ± 1.92, 24.29 ± 2.2 years; Body Mass Index 24.6 ± 4.8, 21.7 ± 2.4 kg/m² were employed in the study. Selected anthropometric parameters of weight and height were used to determine body mass index (BMI), with these are arm-reach forward, elbow to fingertip, hand length and hand width were measured to establish human variations in diversity. Subjects undertook the operation at 5 replicates each, before and after which information about operators’ body pain locations and body physiological changes of heart rates were obtained. Measured parameters were used in the determination of expended energy (EE), physiological cost (PC), oxygen intake (VO₂) and aerobic power (VO₂max). Alongside with these were operational parameters of stroke, pace and time taken to get the operation done and environmental factors of temperature and relative humidity. The results revealed on the average that the BMI (24.61 ± 4.78 kg/m²) in female operators was higher, this corresponded to PC and VO₂, while the VO₂max (34.83 ± 3.30 ml/min/kg) in males is higher. More EE was obtained in female subjects (3.53 ± 3.76 kCal/min) as compared to male subjects (3.42 ± 7.48 kCal/min). The main effects plot of operational factors on EE displayed the stroke made by the subjects during spraying operation as parameter with largest effect on EE. Regression equation for EE and PCI is given as PCI = 1.97 + 25.2 EE, while the P-value at α = 0.05 is 0.000 and R² = 98.8%. Post operational body pain showed that 19 out of 28 subjects incurred at least one type of body pain, with shoulder pain as most frequent. The results of the study suggest that early incidence of fatigue may occur in female operators as compared to the males, and in addition, cumulative trauma at shoulder, back, and upper and lower arm may result over time. Hence, it is recommended that the tank volume should be reduced and the straps for the shoulders should be supported with additional cushion.